Design of a low harmonic five-level inverter based on   a wind power plant using a DC generator with LCL filter

Setiyono Setiyono; Bambang Dwinanto; Dyah Nur’ainingsih; Setiyono Setiyono; Bambang Dwinanto; Dyah Nur’ainingsih

doi:10.55981/j.mev.2026.1138

Design of a low harmonic five-level inverter based on a wind power plant using a DC generator with LCL filter

Setiyono Setiyono, Bambang Dwinanto, Dyah Nur’ainingsih

Abstract

Wind energy is one of the green energy sources that can decrease reliance on fossil fuels such as oil and coal. Wind turbines harness the kinetic energy of the wind and transform it into mechanical energy, which is subsequently converted into electrical energy using a DC generator. The generated DC voltage is transformed into AC voltage by an inverter unit. However, conventional inverters generally produce square-wave outputs with high total harmonic distortion (THD), whereas AC power systems ideally require sinusoidal waveforms with low harmonic content. This research proposes the design of a renewable energy–based power supply system capable of generating both DC and AC voltages for low-power applications. The novelty of the proposed system lies in the use of a five-level inverter with fewer switching devices than the cascaded inverter topology, combined with a T-model inductive-capasitive-inductive (LCL) filter to suppress harmonic distortion at the inverter output. The method involves modeling and simulating the system design using MATLAB Simulink. Simulation results show that the five-level inverter produces an output voltage amplitude of 270 V at 50 Hz with a THD of 28.48 %. After applying the LCL filter (L1 = L2 = 0.01 H and C = 1 mF), the THD decreases to 2.56 % for a 10 Ω resistive load, 2.61 % for an RL load (100 Ω, 0.8 mH), and 2.54 % for an RC load (10 Ω, 1 µF). These values comply with the IEEE 519 standard requiring THD below 5 %. Therefore, the proposed system has potential for small-scale renewable energy applications.

10.55981/j.mev.2026.1138

Keywords

DC generator; five-level inverter; LCL filter; renewable energy; total harmonic distortion; wind energy; wind power plant.

Full Text:

PDF

References

N. A. Pambudi et al., “The future of wind power plants in Indonesia: Potential, challenges, and policies,” Sustainability, vol. 17, no. 3, Art. no. 1312, 2025.

B. P. Resosudarmo, J. F. Rezki, and Y. Effendi, “Prospects of energy transition in Indonesia,” Bull. Indones. Econ. Stud., vol. 59, no. 2, pp. 149–177, 2023.

F. Portillo, A. Alcayde, R. M. Garcia, M. Fernandez-Ros, J. A. Gazquez, and N. Novas, “Life cycle assessment in renewable energy: Solar and wind perspectives,” Environments, vol. 11, no. 7, Art. no. 147, 2024.

T. Hidayat, “Wind power in Indonesia: Potential, challenges, and current technology overview,” in Indonesia Post-Pandemic Outlook: Strategy Towards

Net-Zero Emissions by 2060 from the Renewables and Carbon-Neutral Energy Perspectives, pp. 109–132, 2022.

D. L. Pristiandaru and N. A. Pambudi, “Wind energy in Indonesia: Current status, potential, challenges, opportunities, and future policy,” Indones. J. Energy, vol. 2, no. 2, pp. 65–73, 2019.

M. A. M. Kamal, A. Bostani, J. L. Webber, A. Mehbodniya, and R. Mishra, “Total harmonic distortion reduction-based energy harvesting using a grid-based three-phase system and integral-derivative control,” Comput. Electr. Eng., vol. 109, pp. 1–13, 2023.

Y. Hoon, M. A. Mohd Radzi, M. K. Hassan, and N. F. Mailah, “Control algorithms of shunt active power filter for harmonics mitigation: A review,” Energies, vol. 10, no. 12, Art. no. 2038, 2017.

M. Benaouadj, Z. Boumous, and S. Boumous, “Active harmonic filtering for improving power quality of an electrical network,” J. Eur. Syst. Autom., vol. 55, no. 3, pp. 397–403, 2022.

M. S. Sujatha, S. Sreelakshmi, E. Parimalasundar, and K. Suresh, “Mitigation of harmonics for five-level multilevel inverter with fuzzy logic controller,” Electr. Eng. Electromech., no. 4, pp. 52–56, 2023.

M. Sarebanzadeh, M. A. Hosseinzadeh, C. Garcia, E. Babaei, S. Islam, and J. Rodriguez, “Reduced-switch multilevel inverter topologies for renewable energy sources,” IEEE Access, vol. 9, pp. 120580–120595, 2021.

Marhatang et al., “Design of wind power generator for tambak houses,” J. Electr. Technol. UMY, vol. 7, no. 1, pp. 20–28, 2023.

W. Yandi, M. Y. Puriza, M. Jumnahdi, and R. Kurniawan, “Comparative efficiency of solar panels and wind turbine DC generators as green energy sources in Bangka Island,” IOP Conf. Ser.: Earth Environ. Sci., vol. 599, Art. no. 012037, 2020.

M. S. Sakib, D. T. Griffith, S. Hossain, S. Bayat, and J. T. Allison, “Intracycle RPM control for vertical-axis wind turbines,” Wind Energy, vol. 27, no. 3, pp. 202–224, 2024.

S. U. Handayani, “Effect of winglets on improving wind turbine performance,” J. Vocat. Stud. Appl. Res., vol. 3, no. 1, pp. 5–8, 2021.

F. Merahi et al., “Power control of an autonomous wind energy conversion system based on a permanent magnet synchronous generator with integrated pumping storage,” Sci. Rep., vol. 14, Art. no. 29776, 2024.

D. Devin et al., “Design and CFD simulation of guide vane for multistage Savonius wind turbine,” J. Mechatron. Electr. Power Veh. Technol., vol. 14, no. 2, pp. 186–197, 2023.

P. Kinsler, “Faraday’s law and magnetic induction: Cause and effect, experiment and theory,” Physics, vol. 2, no. 2, pp. 150–163, 2020.

Z. Yang, X. Sun, R. Han, R. Shang, Z. Chen, and X. Liu, “Influence of winding configurations and stator/rotor pole combinations on field back-EMF ripple in switched-flux hybrid-excited machines,” Energies, vol. 17, no. 23, Art. no. 5906, 2024.

A. Sujono, F. Adriyanto, H. Maghfiroh, J. S. Saputro, and A. Ramelan, “Variable-speed DC generator voltage control using a multistage comparator,” J. Electr. Electron. Inf. Commun. Technol., vol. 3, no. 1, pp. 18–22, 2021.

Mudakir, Aripriharta, and A. P. Wibawa, “Analysis of battery energy storage system performance in reducing the impact of variable renewable energy generation intermittency on the electricity system,” J. Mechatron. Electr. Power Veh. Technol., vol. 15, no. 2, pp. 158–176, 2024.

I. Sarbu and C. Sebarchievici, “A comprehensive review of thermal energy storage,” Sustainability, vol. 10, no. 1, Art. no. 191, 2018.

M. Danko, J. Adamec, M. Taraba, and P. Drgona, “Overview of battery state-of-charge estimation methods,” Transp. Res. Procedia, vol. 40, pp. 186–192, 2019.

W. Guan and X. Huang, “A modular active balancing circuit for redox flow battery applied in energy storage system,” IEEE Access, vol. 9, pp. 127548–127558, 2021.

N. H. Baharudin, T. M. N. T. Mansur, F. A. Hamid, R. Ali, and M. I. Misrun, “Performance analysis of DC–DC buck converter for renewable energy application,” J. Phys.: Conf. Ser., vol. 1019, Art. no. 012020, 2018.

W. Indrasari et al., “Development of DC–DC buck converter for solar panel energy storage through load optimization and feedback circuit,” Spektra: J. Fis. dan Apl., vol. 8, no. 3, pp. 143–152, 2023.

D. Khan, M. Qais, I. Sami, P. Hu, K. Zhu, and A. Y. Abdelaziz, “Optimal LCL-filter design for a single-phase grid-connected inverter using metaheuristic algorithms,” Comput. Electr. Eng., vol. 110, Art. no. 108857, 2023.

H. Adamas-Pérez, M. Ponce-Silva, J. D. Mina-Antonio, A. Claudio-Sánchez, O. Rodríguez-Benítez, and O. M. Rodríguez-Benítez, “A new LCL filter design method for single-phase photovoltaic systems connected to the grid via micro-inverters,” Technologies, vol. 12, no. 6, Art. no. 89, 2024.

R. Eswaramoorthi, “Development of a low-harmonic distortion three-phase inverter for renewable grid integration,” Trans. Power Electron. Renew. Energy Syst., vol. 2, no. 2, pp. 20–28, 2026.

G. Priyanka, J. S. Kumari, D. Lenine, P. S. Varma, S. S. Madhuri, and V. Chandu, “MATLAB/Simulink environment-based power quality improvement in photovoltaic system using multilevel inverter,” Electr. Eng. Electromech., vol. 45, no. 2, pp. 43–48, 2023.

Suroso, D. T. Nugroho, A. N. Azis, and T. Noguchi, “Simplified five-level voltage-source inverter with level phase-shifted-carrier-based modulation technique,” Indones. J. Electr. Eng. Comput. Sci., vol. 13, no. 2, pp. 461–468, 2019.

M. Karakılıç, H. Hataş, and M. N. Almali, “Design of a 21-level multilevel inverter with a minimum number of devices,” Int. J. Circuit Theory Appl., vol. 51, no. 12, pp. 5705–5723, 2023.

E. Parimalasundar, S. Muthukaruppasamy, R. Dharmaprakash, and K. Suresh, “Performance investigations of a five-level reduced-switch-count H

bridge multilevel inverter,” Electr. Eng. Electromech., vol. 6, no. 6, pp. 58–62, 2023.

M. I. D. Prasetyo et al., “Integration of a bidirectional cellu in a quasi-Z-source inverter for CMV reduction and pure sinusoidal waveform,” J. Mechatron. Electr. Power Veh. Technol., vol. 16, no. 2, pp. 266–277, 2025.