Adaptive frequency regulation of an LPG generator using an assistive model-free iterative learning controller

Inov Ivandany; Arya Kusumawardana; Muhammad Afnan Habibi; Muhammad As'ad Sahroni; Inov Ivandany; Arya Kusumawardana; Muhammad Afnan Habibi; Muhammad As'ad Sahroni

doi:10.55981/j.mev.2026.1372

Adaptive frequency regulation of an LPG generator using an assistive model-free iterative learning controller

Inov Ivandany, Arya Kusumawardana, Muhammad Afnan Habibi, Muhammad As'ad Sahroni

Abstract

Mechanical speed governors in small generator sets often provide only coarse frequency regulation, leading to steady-state error and poor transient recovery under load disturbances. To address this limitation, this study proposes a hybrid governor for an (liquefied petroleum gas) LPG-converted generator, in which the built-in mechanical governor is retained as the primary stabilizing layer, and a model-free iterative learning control (ILC) is added as an assistive electronic controller. The proposed method was validated experimentally under dynamic multi-step load disturbances and internal parameter shifts. In the dynamic load test, the proposed hybrid ILC achieved the lowest root mean square error (RMSE) of 0.9144 Hz, compared with 0.9581 Hz for the (proportional-integral) PI-controller benchmark and 1.5512 Hz for the mechanical governor. This corresponds to an RMSE improvement of 41.05 % relative to the mechanical governor and 4.56 % relative to the PI-controller benchmark. In terms of relative tracking accuracy, both electronic controllers substantially reduced the mean absolute percentage error (MAPE) relative to the mechanical governor, with the proposed hybrid ILC achieving the lowest value of 1.14 %, slightly lower than 1.15 % for the PI-controller and much lower than 2.04 % for the mechanical governor. Under internal parameter detuning, the proposed method maintained better regulation performance, with RMSE improvements reaching 79.68 % relative to the mechanical baseline. These results show that the proposed hybrid model-free ILC improves transient response, tracking accuracy, and robustness, while preserving the original mechanical governor as a practical baseline controller.

10.55981/j.mev.2026.1372

Keywords

Electric Governor; Frequency Stabilization; Iterative Learning Control (ILC); LPG-Converted Generator

Full Text:

PDF

References

C. Chi, H. Zhao, and J. Han, “Study on quantitative evaluation index of power system frequency response capability,” Energies, vol. 15, no. 24, 2022.

Mudakir, Aripriharta, and A. P. Wibawa, “Analysis of battery energy storage system (BESS) performance in reducing the impact of variable renewable energy generation intermittency on the electricity system,” J. Mechatronics, Electr. Power, Veh. Technol., vol. 15, no. 2, pp. 158–176, 2024.

I. I. Novendra, I. M. Wirawan, A. Kusumawardana, and A. K. Latt, “Optimization of load frequency control using grey wolf optimizer in micro hydro power plants,” J. Mechatronics, Electr. Power, Veh. Technol., vol. 14, no. 2, pp. 166–176, 2023.

Sujito, R. R. Hadi, L. Gumilar, A. I. Syah, M. Z. Falah, and T. H. Duy, “Long-term forecasting for growth of electricity load based on customer sectors,” J. Mechatronics, Electr. Power, Veh. Technol., vol. 13, no. 2, pp. 214–221, 2022.

N. Nahak, J. Samal, S. K. Swain, S. Satapathy, and A. K. Patra, “Enhancement of oscillatory stability of a grid integrated microgrid by optimized governor damping action,” in Lecture Notes in Electrical Engineering, vol. 974, 2023, pp. 119–132. [6] A. Big-Alabo, “On the nonlinear asymmetric vibrations of the unforced Watt governor: An exact analysis,” Adv. Mech. Eng., vol. 17, no. 6, Jun 2025.

A. C. Barajas et al., “LFC and AVR combined regulation of multi-area interconnected power system with low inertia and high penetration of flexible generation technologies,” in 2023 IEEE International Autumn Meeting on Power, Electronics and Computing (ROPEC), IEEE, Okt 2023, pp. 1–6.

S. Gorb, M. Levinskyi, and M. Budurov, “Sensitivity optimisation of a main marine diesel engine electronic speed governor,” Sci. Horizons, vol. 24, no. 11, pp. 9–19, Feb 2022.

J. S. Bryant, P. Sokolowski, R. Jennings, and L. Meegahapola, “Synchronous generator governor response: performance implications under high share of inverter-based renewable energy sources,” IEEE Trans. Power Syst., vol. 36, no. 3, pp. 2721–2724, 2021.

W. Adhyaksa, M. Anshar, and R. Tandioga, “Analisis pengaruh perubahan frekuensi sistem terhadap kinerja governor pada PLTA Bakaru Unit 1,” J. Tek. Mesin Sinergi, vol. 23, no. 1, pp. 82–87, Sep 2025.

N. L. Thotakura, C. R. Burge, and Y. Liu, “Impact of the exciter and governor parameters on forced oscillations,” Electronics, vol. 13, no. 16, pp. 3177, Aug 2024.

A. Shrestha and F. Gonzalez-Longatt, “Frequency stability issues and research opportunities in converter dominated power system,” Energies, vol. 14, no. 14, pp. 4184, Jul 2021.

V. T. Nguyen, T. L.-T. Tran, D. H. Tuan, D. C. Hien, V. P. Nguyen, and V. Van Huynh, “Load frequency control for integrated hydro and thermal power plant power system,” Int. J. Electr. Comput. Eng., vol. 15, no. 4, pp. 3583, Aug 2025.

S. Ebrahimian, H. Shahinzadeh, H. Nafisi, M. Bagheri, M. Moazzami, and E. Etemadnia, “Enhanced frequency regulation in islanded microgrids using a machine learning-assisted linear-quadratic regulator,” in 2025 6th International Conference on Optimizing Electrical Energy Consumption (OEEC), IEEE, Feb 2025, pp. 1–7.

M. Jabari, D. Izci, S. Ekinci, M. Bajaj, V. Blazek, and L. Prokop, “A novel artificial intelligence based multistage controller for load frequency control in power systems,” Sci. Rep., vol. 14, no. 1, pp. 29571, Nov 2024.

Sasikumar K., Velmurugan K., “Optimal Frequency and Voltage Control of Self-Excited Induction Generator for Wind Power Generation Using PWM Converter and Load Management,” Int. Res. J. Mod. Eng. Technol. Sci., Jul., 2023.

Z. Kou, J. Sun, G. Su, M. Wang, and H. Yan, “Hybrid-based model-free iterative learning control with optimal performance,” Int. J. Syst. Sci., vol. 54, no. 10, pp. 2268–2280, Jul 2023.

M. H. Shahna and J. Mattila, “Model-free generic robust control for servo-driven actuation mechanisms with layered insight into energy conversions,” 2025 American Control Conference (ACC), Aug., 2025.

Y. Dou and E. Prempain, “Green ILC: A Novel Energy-Efficient Iterative Learning Control Approach,” Sensors, vol. 24, no. 23, pp. 7787, Des 2024.

R. Hou, L. Jia, X. Bu, and C. Peng, “Event‐triggered model‐free neuroadaptive iterative learning control via controller dynamic linearization and application to impact load frequency regulation,” Int. J. Robust Nonlinear Control, vol. 35, no. 6, pp. 2273–2287, Apr 2025.

A. F. Mohammed, H. M. Marhoon, N. Basil, and A. Ma’arif, “A new hybrid intelligent fractional order proportional double derivative + integral (FOPDD+I) controller with ANFIS simulated on automatic voltage regulator system,” Int. J. Robot. Control Syst., vol. 4, no. 2, pp. 463–479, Apr 2024.

M. A. El-Hameed, M. Saeed, A. Kabbani, and E. Abd El-Hay, “Efficient load frequency controller for a power system comprising renewable resources based on deep reinforcement learning,” Sci. Rep., vol. 15, no. 1, pp. 18379, May 2025.

D. T. T. Huyen, V. Van Hoc, and N. T. T. Hoa, “Proportional derivative – type iterative learning algorithm for a motion control system,” Int. J. Robot. Control Syst., vol. 3, no. 2, pp. 304–314, Apr 2023.

W. Y. Fu, X. D. Li, and T. Qian, “Data-driven ILC algorithms using AFD in frequency domain for unknown linear discrete-time systems,” J. Franklin Inst., vol. 359, no. 6, pp. 2445–2462, 2022.

W.-Y. Fu and Z. Nie, “Frequency-domain-based forgetting-factor data-driven iterative learning control algorithm,” in 2024 IEEE 13th Data Driven Control and Learning Systems Conference (DDCLS), IEEE, May 2024, pp. 878–882.

V. T. Nguyen, T. B. T. Truong, Q. V. Truong, H. V. P. Nguyen, and M. Q. Duong, “Iterative learning control for virtual inertia: Improving frequency stability in renewable energy microgrids,” Sustainability, vol. 17, no. 15, pp. 6727, Jul 2025.

W.-H. Hsieh, Y.-S. Chen, and S.-T. Wu, “Iterative learning control of an inverse novel ball screw transmission system,” J. Intell. Fuzzy Syst., vol. 40, no. 4, pp. 8043–8052, Apr 2021.

Q. Yao, H. Jahanshahi, S. Bekiros, S. F. Mihalache, and N. D. Alotaibi, “Gain-scheduled sliding-mode-type iterative learning control design for mechanical systems,” Mathematics, vol. 10, no. 16, pp. 3005, Aug 2022.

MathWorks. Iterative learning control. MATLAB Help Center. [Online].

R. J. Hyndman and A. B. Koehler, “Another look at measures of forecast accuracy,” Int. J. Forecast., vol. 22, no. 4, pp. 679–688, 2006.

A. de Myttenaere, B. Golden, B. Le Grand, and F. Rossi, “Mean absolute percentage error for regression models,” Neurocomputing, vol. 192, pp. 38–48, 2016.

C. D. Lewis. Industrial and business forecasting methods : A practical guide to exponential smoothing and curve fitting. 1982. [Online].